Advisory Report

October 2000

Defective Furnaces Pose Fire Threat
As many as 30 fires and damage to homes have been attributed to defective furnaces.  The U.S. Consumer Product and Safety Commission (CPSC) is warning consumers in California that certain gas-fired horizontal forced-air furnaces present a substantial risk of fire.

Consolidated Industries (formerly Premier Furnace Company) manufactured approximately 190,000 defective furnaces from 1983 through 1994 under many different brand names.  Most of the furnaces were manufactured under the Premier/Consolidated labels.

All of the furnaces can be identified by the fact that the are equipped with steel control rods installed above the burners.  These steel rods were required to satisfy California air quality regulations for nitrous oxide emissions.

Many of these furnaces are still in use.  Normally, the furnaces are installed in attics, although some may be installed in crawl spaces.  The CPSC is warning consumers to have their gas-fired furnaces inspected by a licensed heating contractor to determine whether the furnaces are subject to this safety alert.  The contractor should also determine whether the burners and/or heat exchangers of units are damaged, or whether wood under or near the furnaces shows signs of damage, such as charring or blackening.  If this is the case, the furnace should be replaced or repaired immediately.

Because Consolidated is currently in bankruptcy liquidation, the availability of repair parts is at this time unresolved.  However, there is ongoing private litigation which could enable consumers to recover at least some of their out-of-pocket expenses for replacement or repair of the furnaces.

Suggestions for improving the fire safety of all horizontal forced-air furnaces in attics include:

• Protect the wood deck or rafters on which the furnace is mounted by covering it with a non-combustible material such as cement board that extends a minimum of 12 inches past the side of the furnace.
• Provide an air space beneath the furnace.  A licensed contractor can perform this work and can offer the homeowner several ways to accomplish this.
• Make sure the furnace is installed correctly and serviced at least annually.  The inspection should include a safety inspection of the burner assembly and heat exchanger.
• Install an ionization-type smoke detector inside the attic to provide an early warning of smoke or fire.

Learn more about furnaces, or read U.S Inspect's Key Findings and Position Paper on Consolidated Furnaces.  For additional information, consumers should contact CPSC's toll-free hotline at (800) 638-2772.

Other stories in this month's report:

Battling the Formosan Termite

Builder Sued Over EIFS

Feeling Well Contaminated?

Visit the Advisory Report Archives

Read U.S. Inspect's Position Paper on Consolidated Furnaces